Free 7 Day Trial RV GPS App RV Trip Planner Campground Reviews RV Maintenance Free 7 Day Trial ×
 

Go Back   Keystone RV Forums > Keystone Fleet | Keystone RV Models > Travel Trailers
Click Here to Login

Reply
 
Thread Tools Display Modes
 
Old 05-30-2015, 08:23 AM   #1
rtltspd
Junior Member
 
Join Date: Mar 2013
Location: sparks nv
Posts: 12
Water Pump Problems

We have a 2014 25ft rls Cougar the water pump has been a pain since day one. It will run when you are not hooked up to city and it just putts and does not run hard. I have checked all the lines in the trailer more than once. To make things worst it does not act up all the time. The only thing I have not done is replace the pump.
__________________

rtltspd is offline   Reply With Quote
Old 05-30-2015, 09:14 AM   #2
sourdough
Site Team
 
Join Date: Feb 2014
Location: W. Texas
Posts: 11,617
I'm not sure I understand. "putts and doesn't run hard"? Is it not priming or just putting out a small amount of water or none ?
__________________

sourdough is offline   Reply With Quote
Old 05-30-2015, 11:17 AM   #3
Ken / Claudia
Senior Member
 
Join Date: Nov 2012
Location: Fruitland
Posts: 3,030
I do not understand either. Are you saying the water pressure is to low and by checking the lines what did you check. Guessing at what your saying, maybe air getting in a water line.
__________________
2013 24RKSWE (27ft TT) Cougar 1/2 ton series
2013 Ford F350 4x4 CC 6.7 engine, 8 ft bed 3.55 rear end lariat package
Retired from Oregon State Police in 2011 than worked another 9.5 years as a small town traffic cop:
As of 05-2020, I am all done with 39 years total police work. No more uniforms for me.
Ken / Claudia is offline   Reply With Quote
Old 05-30-2015, 12:48 PM   #4
Rick
Senior Member
 
Join Date: Jul 2011
Location: So. Cal
Posts: 136
I agree with Ken/Claudia, or you could have a leak. Do the cheap things first. Look in all your cupboards where there's water connections to verify they're not leaking. If that's good, purge the lines of any possible air. Turn the pump on and open all the water outlets 1 at a time (hot and cold-don't need heater on for this) to purge any air from the system (and outside water outlets). If that doesn't fix the problem, you might be able to do some minor adjustments to the pump itself. Per the Shurflo water pump site for more things to check -
Correct voltage to pump +/- 10%
Loose drive assembly or pump head screws
Are the valves held open by debris or is the rubber swollen?
Pressure switch operation. By-pass set higher than shut-off

Hope this helps!

Rick
Rick is offline   Reply With Quote
Old 06-01-2015, 08:49 PM   #5
00Buckshot
Junior Member
 
Join Date: Aug 2014
Location: Anoka MN
Posts: 6
We recently purchased a 2007 TT and the previous owners had never ran the water. After getting it home I discovered the toilet valve needed to be replaced so I ordered one and replaced it. I then fired up the pump and all was good, so I thought. I seen a previous post regarding isolating the pump to make it quieter and while I was looking for the pump, I started to pull access panels until I heard a water leak. Long story short, the factory screwed right through the water line for the hot side of the shower. Just saying, it can/does happen.

Regards, Chad
__________________
2014 RAM 1500
2007 Springdale 266RELL GL
00Buckshot is offline   Reply With Quote
Old 06-02-2015, 10:26 AM   #6
cb1000rider
Gone Traveling
 
Join Date: May 2015
Location: Texas
Posts: 101
Chad one thing coming from a 2004 model - new SureFlow pumps have gotten much more quiet... Probably the same thing with your model.
cb1000rider is offline   Reply With Quote
Old 06-04-2015, 12:27 PM   #7
rtltspd
Junior Member
 
Join Date: Mar 2013
Location: sparks nv
Posts: 12
Thanks the the one thing I have not tried is to purge the lines Iwill give it a try. Tm
__________________

rtltspd is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Forum Jump

Powered by vBadvanced CMPS v3.2.3
Disclaimer:

This website is not affiliated with or endorsed by the Keystone RV Company or any of its affiliates in any way. Keystone RV® is a registered trademark of the Keystone RV Company.


All times are GMT -8. The time now is 07:13 PM.


Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
×