|
01-20-2019, 09:54 AM
|
#1
|
Junior Member
Join Date: Sep 2018
Location: Stanton
Posts: 1
|
Tow Vehicle Brake Line Failure
Just a heads up....I have a 2003 Chev 2500 with 8.1L engine and Allison tranny for towing my fifth wheel. Last summer I had the unfortunate experience of having a brake line of the truck blowing out when I needed it most on I-94 in Michigan. Came close to flipping the trailer. As it turned out, the brake line rusted out just in front of the booster pump under the driver side of the cab. I thought brake lines were stainless, not true. Apparently it is not just GM vehicles with steel lines. After getting the truck and trailer fixed I changed all the brake lines to stainless. Dorman has pre-bent kits for a bunch of trucks. While replacing the lines, 2 of the other 4 lines collapsed without much force. All in the same location. This truck only has 110k on her. In the garage most of the time. I just use her to tow, plow my drive and lumber yard runs. If your truck is over 10 years old, I recommend checking your brake lines.
|
|
|
01-20-2019, 12:49 PM
|
#2
|
Senior Member
Join Date: Jul 2017
Location: Muskegon
Posts: 356
|
Your lucky they lasted that long. The 02 that I bought new needed them in either 07 or 08. It's be all over the net for years that the lines rusted out very quickly on those trucks
__________________
07 GMC CC LB dually LBZ, Idaho Rob EFI, DeeZee boards, 50 gal TransferFlow inbed tank
05 32' Montana Mountaineer 5th wheel 2 slides
1941 Ford cpe 454/700R4
1917 T roadster 270 Hemi/4 spd
34' car trailer w/63" semi sleeper on the front
|
|
|
01-21-2019, 02:13 AM
|
#3
|
Senior Member
Join Date: Aug 2016
Location: Rincon
Posts: 192
|
Similar issue a few years back and the mechanic I used had seen lots of these and had a thought why is was happening to so many trucks that were stored in garages.
He thought it was due to the trucks being used in the rain and snow then being put into unheated garage and sitting for weeks before being used again so the undercarriage never really got to be wasted and dry out like a truck that sits outside.
Sounded reasonable to me at the time.....
__________________
2017 Ram 3500 CC Cummins
2011 Keystone Laredo 266 RL
|
|
|
01-21-2019, 07:10 AM
|
#4
|
Senior Member
Join Date: Jul 2017
Location: Muskegon
Posts: 356
|
It wasn't just garaged trucks. Mine sat outside 99.9% of the time. I felt it showed the cheapness of materials
__________________
07 GMC CC LB dually LBZ, Idaho Rob EFI, DeeZee boards, 50 gal TransferFlow inbed tank
05 32' Montana Mountaineer 5th wheel 2 slides
1941 Ford cpe 454/700R4
1917 T roadster 270 Hemi/4 spd
34' car trailer w/63" semi sleeper on the front
|
|
|
01-30-2019, 12:38 PM
|
#5
|
Senior Member
Join Date: Jun 2018
Location: Swanton
Posts: 188
|
Just replaced the lines on my 06 GMC. A friend has the same year and had his replaced two years ago. I used copper-nickle lines. The liquid rust they are putting on the roads up here is terrible.
|
|
|
01-30-2019, 12:56 PM
|
#6
|
Senior Member
Join Date: May 2018
Location: Markham, Ontario
Posts: 1,942
|
Aren't the northern states and Canada awesome for salt and rust?
__________________
Dan & Serena
2019 GMC SIERRA 2500 HD SLE
2015 Cougar X-Lite 29 RET
|
|
|
01-30-2019, 02:07 PM
|
#7
|
Senior Member
Join Date: Jun 2018
Location: Swanton
Posts: 188
|
The salt was bad enough, but the brine mixture they put down. I think the car manufacturers are paying them to put down. I call it liquid rust.
|
|
|
01-30-2019, 03:44 PM
|
#8
|
Senior Member
Join Date: Dec 2017
Location: Lisbon
Posts: 551
|
Had that happen to my old 2004 Nissan Titan last year. Pulled the trailer to Maine and just as I was pulling in the campground the brake light came on. Found a leak in the same spot as the OP. Had a local shop replace all the lines and hoses while I was up there. They also noticed one of the lower control arms was rusted pretty bad. After I got home I found the control arm was starting to bend it had rusted so bad. Had that replaced and then got rid of the truck and got my new Ford.
__________________
2018 Keystone Cougar 22RBS
2020 Ford F-350 XLT SC SRW 6.7l Powerstroke.
|
|
|
01-30-2019, 04:13 PM
|
#9
|
Senior Member
Join Date: Jul 2017
Location: Muskegon
Posts: 356
|
Cavediver is that Swanton Oh.?
__________________
07 GMC CC LB dually LBZ, Idaho Rob EFI, DeeZee boards, 50 gal TransferFlow inbed tank
05 32' Montana Mountaineer 5th wheel 2 slides
1941 Ford cpe 454/700R4
1917 T roadster 270 Hemi/4 spd
34' car trailer w/63" semi sleeper on the front
|
|
|
01-30-2019, 10:56 PM
|
#10
|
Senior Member
Join Date: Oct 2018
Location: Panama City
Posts: 146
|
This is one of the few items that the manufacturer ought to be held to a higher standard. If it was required the actual cost per vehicle wouldn't be that great for all stainless steel lines.
Luckily I live in the arid Idaho climate and this has never been an issue. Even though, growing up in the rust belt west side of Cleveland I've always liberally douched my cars undercarriage especially in the spring once it warms enough to regularly wash the vehicles.
__________________
2019 Bullet 261 RBSWE
Tow vehicle 2015 Ram 1500 Bighorn 5.7L
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
All times are GMT -8. The time now is 03:05 PM.