As Marshall posted, you're probably overloading the generator with something that you "didn't realilze is on and drawing power"...
First, I'd suspect the refrigerator. If it's in "AUTO" then as soon as you plug in the generator, it will switch to shore power (ELEC) mode. You need to turn it to GAS mode to stop it from automatically switching.
Second is the water heater. Many people use the electric element as a way to save on propane and then "forget to turn it off" when there's no shore power, they just "carry on by turning on the propane"... As soon as you connect the generator, the water heater will immediately start "cooking water on electricity"...
The two items, refrigerator and water heater, will draw about 500 watts and 1100 watts from the generator. That's 4.2 amps for the refrigerator and 9.2 amps for the water heater. Using the wattage figures, that's 1600 watts, over half the generator output, leaving way too little for the air conditioner to run, certainly far too little for it to start. Even with the "surge/momentary capacity of 3100 watts, those two items will be drawing more than half the generator "surge capacity"...
Additionally, the WFCO converter will draw "somewhere between 4 amps (480 watts) at "minimum power" and 10 amps (1200 watts) at full capacity, depending on the charge state of the battery bank and the amount of 12 volt power being consumed by lights, control system or remote control systems in the trailer, you could be using "every available watt" without even trying to start the air conditioner.
As you can see, if all three of the above are on and drawing power or if any two or even one of those are on when you try to start the air conditioner, you'll overload the generator and cause it to "shut down" to prevent damage.
So, as Marshall suggested, turn off all the "extra draws" and see if the air conditioner will run with "only the main power panel circuit breaker and the Air Conditioner circuit breaker" in the on position. After that, try to turn on the converter circuit breaker and see if that will run...
Dometic, a manufacturer of RV air conditioners, recommends a MINIMUM generator output of 3500 watts for a single air conditioner and 5500 watts for a RV with two rooftop units.... The reason for those "much greater wattage outputs" is to compensate for some of the "unseen wattage users" like the refrigerator and the converter.....
Bottom line, I'd suspect you're significantly overloading your generator with things you didn't even realize are using generator power......
__________________
John
2015 F250 6.7l 4x4
2014 Cougar X Lite 27RKS
|