Journey with Confidence RV GPS App RV Trip Planner RV LIFE Campground Reviews RV Maintenance Take a Speed Test Free 7 Day Trial ×
 

Go Back   Keystone RV Forums > Keystone Fleet | Keystone RV Models > Toy Haulers
Click Here to Login

Reply
 
Thread Tools Display Modes
 
Old 03-01-2012, 01:50 PM   #1
VEGASRAPTORJIM
Junior Member
 
Join Date: Mar 2012
Location: LAS VEGAS
Posts: 3
2006 Raptor 3712ts Slide Problem

New member and first post. Recommendations and suggestions for the following; This unit has a single hydraulic unit to extend 3 slides, the bedroom goes first then the kitchen second and then the large slide for the living room. About half way through either IN or OUT cycle the final slide (living room) will stop motion. If I wait a minute or so then try again, it completes the slide activity with all slides out. Hydraulic fluid level is fine with no leaks. I am guessing it is a relay in the unit that is overheating thus stopping motion until it cool or resets. Please advise where this relay is located, and if it is a DIY fix. Whom could I purchase the relay from and thanks in advance and to the moderators. Jim
VEGASRAPTORJIM is offline   Reply With Quote
Old 03-01-2012, 02:20 PM   #2
Ron
Senior Member
 
Ron's Avatar
 
Join Date: Mar 2011
Location: Washington State
Posts: 859
Welcome Jim to the forum. As far as your hydraulic slides, yes the order the slides extend and retract is lighter slides first go in and out both ways. As far as a relay, If you look on the control panel near your hydraulic pump location, there are relay's built into the circuit board. The relays may be getting weak at this point depending on how much they have been used as far as overloading them and kicking out. I would probably have someone hold there hand near the control panel listen and feel that area to see if there is noise of clicking or sound and that will tell you if you have the right location. Your Raptor may be different being an 06 model but I think they are building them the same as the new ones today. Hope this helps. Happy Campin.............Ron
__________________
Ron
99 Freightliner FL70 Western Hauler CC 300 HP Cat/Chipped/ Allison Auto
12 Montana 3800RE/Level-Up Auto Leveling/Slide Toppers/MorRyde Hitch/VuQube 2000
01 F350 7.3 PSD Crew Cab DRW 4X4 6 Speed/Chipped


Ron is offline   Reply With Quote
Old 03-01-2012, 02:56 PM   #3
JoeofNSB
Senior Member
 
JoeofNSB's Avatar
 
Join Date: Nov 2011
Location: New Smyrna Beach, FL
Posts: 129
I have the same problem with my 3612DS and it is one of the circuit breakers tripping and then reseting. Some day when I have an extra "body" with me I will be able to figure out which one it is. Since they are right next to each other it is hard to tell by the click when it resets and by the time I go from the switch to the pump to look at my meter it resets!! One day I will figure it out. Then I will post my findings. Good luck in your search - hope this helps some.
__________________

Joe & Terri
2005 Raptor 3612DS ToyHauler "the Pearl"
2001 Ford F550 4X4 (or is that 4X6!!) 7.3L Crew Cab - "Jack Sparrow"
2010 Victory CrossCountry
2012 Bushtec Spartan trailer (behind Victory)
2006 Suzuki DR650
Trek EX8 Mountain Bike
Trek 7100 Hybrid
48" Penny Farthing Bike
Haro Sonix International Mountain Bike
Haro Sanford Road Bike with a B.O.B Trailer
JoeofNSB is offline   Reply With Quote
Old 12-11-2012, 12:54 PM   #4
McCainK
Junior Member
 
Join Date: Dec 2012
Location: Paradise, CA
Posts: 2
I just had the same problem on our raptor 3612 ds. Changed the breaker that connects to the slide pump in the battery compartment. Works great with no pauses. Before it would pause at least three times when it was trying to push the main slide in or out. Autozone didn't have a 50 amp which was suggested but I used a 40 amp and absolutely satisfied. Thanks to this forum I've been able to trouble shoot a lot of the issues we've had
McCainK is offline   Reply With Quote
Old 12-11-2012, 01:00 PM   #5
maxx1963
Senior Member
 
Join Date: Jun 2012
Location: Wa
Posts: 146
are you sure your 2 small slides are hydraulic? My bedroom slide is electtric with a hydraulic living room.
__________________

2005 2500HD CCLB Duramax. LBZ mouthpiece, factory CAI mod, Diamond eye "quiet" downpipe back exhaust/ Reese elite under bed rail hitch
2008 Fuzion 362
2008 KFX 700
2007 Yamaha Wolverine(wife's)
2002 Suzuki LT-A50(daughter's)
1995 Yamaha G14 golf cart
maxx1963 is offline   Reply With Quote
Old 01-07-2013, 02:31 PM   #6
frisco9312
Junior Member
 
Join Date: Jan 2013
Location: kansas
Posts: 1
cannot locate for sure what relay (or relays) is being talked about, i have found a series of 3 relays in a series on the inner wall by the pump, is that the ones or is it on the pump?
frisco9312 is offline   Reply With Quote
Old 01-07-2013, 02:40 PM   #7
Htfiremedic
Senior Member
 
Htfiremedic's Avatar
 
Join Date: Oct 2012
Location: Hickory Taver SC
Posts: 381
I had a similar problem with my Fuzion.
Oddly enough, my remote battery was weak and triggering a pause when using the remote, or the wall switch.
Just food for thought.
Htfiremedic is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Forum Jump

» Featured Campgrounds

Reviews provided by

Powered by vBadvanced CMPS v3.2.3
Disclaimer:

This website is not affiliated with or endorsed by the Keystone RV Company or any of its affiliates in any way. Keystone RV® is a registered trademark of the Keystone RV Company.


All times are GMT -8. The time now is 02:43 AM.


Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.