|
02-15-2020, 12:27 AM
|
#1
|
Junior Member
Join Date: Feb 2020
Location: Soddy Daisy
Posts: 13
|
28RKS Water Heater
Good morning folks. My 2017 Cougar RKS was delivered to me yesterday. I was hooking everything up but could not find the access to the water heater. it is in bypass mode and I need to take it out of bypass so I can fill it and use it. Can someone direct me please? Thanks guys!
__________________
Troy & Debra, married 41 years, & Sarah our Borador
2017 Keystone Cougar 28RKS
2015 Ford Super Duty Lariat 6.7
Andersen Aluminum 5th Wheel Hitch
|
|
|
02-15-2020, 04:26 AM
|
#2
|
Senior Member
Join Date: May 2018
Location: Markham, Ontario
Posts: 1,942
|
Hey Troy, Google is your friend
It's easier to google your question it will most times lead you back to the forum with the correct link or one that might give you a better idea where to look.
Good luck
__________________
Dan & Serena
2019 GMC SIERRA 2500 HD SLE
2015 Cougar X-Lite 29 RET
|
|
|
02-15-2020, 05:39 AM
|
#3
|
Site Team
Join Date: Oct 2011
Location: Joppa, MD
Posts: 11,752
|
Easiest way I know to find it is to go outside. Look for the exhaust vent located in an acess panel. Note where it is, i.e. 10' back from front door, or 2' in front of kitchen window for example. Then go inside and look at where that aligns up to. You may have to remove a panel inside a cabinet to get to the valve.
__________________
Marshall
2012 Laredo 303 TG
2010 F250 LT Super Cab, long bed, 4X4, 6.4 Turbo Diesel
|
|
|
02-15-2020, 05:40 AM
|
#4
|
Junior Member
Join Date: Sep 2019
Location: Hastings
Posts: 17
|
You can access the water heater by removing the wall between the pass through storage and water heater location. I believe it was two screws. The water pump is also behind that wall as well just FYI.
__________________
2019 Cougar 338RLK
2016 Ram 2500 Limited CC 6.7L
|
|
|
02-15-2020, 08:15 AM
|
#5
|
Senior Member
Join Date: Mar 2014
Location: Mountain Home, Idaho
Posts: 3,013
|
__________________
2007 GMC Classic club cab 4x4 Duramax LBZ
2014 Alpine 3010 RE. 34 foot fifth wheel
|
|
|
02-16-2020, 12:04 PM
|
#6
|
Junior Member
Join Date: Feb 2020
Location: Soddy Daisy
Posts: 13
|
Quote:
Originally Posted by Northofu1
Hey Troy, Google is your friend
It's easier to google your question it will most times lead you back to the forum with the correct link or one that might give you a better idea where to look.
Good luck
|
Thanks for the Google advice friend. I did go to Google, and also searched this forum from front to back and still, I can't get hot water that is in the water heater to come out of the faucets anywhere!! I have tried everything I have read, from making sure outside shower was tuned off at the knobs instead of the off-on valve, to checking the check valve, which I took out and made sure it wasn't clogged! I have hot water in my heater but not in the camper. I have a single bypass valve, which was, but is not now in bypass, with a check valve on the hot side of the heater. When I turn on hot water, I have great flow, but it's cold. What else could it possibly be? If I had a clog, would I not have slow flow from the hot side of my faucets? After 3 hours out in pouring rain, I'm over this! Anyone got an idea? Thanks
__________________
Troy & Debra, married 41 years, & Sarah our Borador
2017 Keystone Cougar 28RKS
2015 Ford Super Duty Lariat 6.7
Andersen Aluminum 5th Wheel Hitch
|
|
|
02-16-2020, 12:23 PM
|
#7
|
Site Team
Join Date: Jun 2009
Location: Venice
Posts: 5,346
|
What you describe is what you get when valve is "IN" bypass position. Turn it back again and see what you get. JM2¢, Hank
__________________
Hank & Lynn
2007 Cougar 290RKS, E-Z Flex, 16" XPS RIBs ( SOLD .. Gonna miss her ... looking for new 5r)
2004.5 Dodge 2500 QC, LB, 5.9HO, WestTach gauges, Ride-Rite
|
|
|
02-16-2020, 12:31 PM
|
#8
|
Junior Member
Join Date: Feb 2020
Location: Soddy Daisy
Posts: 13
|
Thanks for the reply Hank. I have tried it in both positions, nothing changes. Just cold water....
__________________
Troy & Debra, married 41 years, & Sarah our Borador
2017 Keystone Cougar 28RKS
2015 Ford Super Duty Lariat 6.7
Andersen Aluminum 5th Wheel Hitch
|
|
|
02-16-2020, 12:43 PM
|
#9
|
Senior Member
Join Date: May 2018
Location: Markham, Ontario
Posts: 1,942
|
Try closing bypass valve halfway. Sounds odd,.my uncles trailer bad to run that way. Let it run for a few minutes.
__________________
Dan & Serena
2019 GMC SIERRA 2500 HD SLE
2015 Cougar X-Lite 29 RET
|
|
|
02-16-2020, 01:04 PM
|
#10
|
Site Team
Join Date: Jul 2014
Location: Modesto
Posts: 20,345
|
At this point can you post a pic of YOUR water heater back side with the bypass valve?
__________________
2012 Copper Canyon 273FWRET being towed by a 1994 Ford F350 CC,LB,Dually diesel.
Airlift 5000 bags, Prodigy brake control, 5 gauges on the pillar.Used to tow a '97 Jayco 323RKS.
Now an RVIA registered tech. Retired from Law enforcement in 2008 after 25+ yrs.
|
|
|
02-16-2020, 01:49 PM
|
#11
|
Junior Member
Join Date: Feb 2020
Location: Soddy Daisy
Posts: 13
|
Hey Chuckster, I am in for the evening. So I won't be going back out in this weather today. My bypass valve lever is in line with the cold water line, and perpendicular to the bypass line between the hot and cold. As valves go, it is pointing in the same direction as the flow of cold water. And I have tried it in both directions, and the result is the same. It's almost as if there is a crossed water line somewhere in the unit. I hesitate to say this, but my world is electricity, valves, and nuclear construction! So with that said, watch it be something stupidly easy! I just haven't found it yet! This is a used rig, and who knows what has been done prior to my ownership. I know the water is hot in the heater, I have drained it twice and it's scalding when it comes out. I have removed any shower head thumb valves form the equation, so both shower heads, inside and outside are straight plumbed! only the knobs turn them off. And I have great pressure, and the air has been bled! I have ordered a tankless Girard water heater and it will be here Thursday. This will be my second tankless I've installed in a camper. The first in my smaller camper is awesome. So is the one in my home! I just don't have time for all of this at the moment!
__________________
Troy & Debra, married 41 years, & Sarah our Borador
2017 Keystone Cougar 28RKS
2015 Ford Super Duty Lariat 6.7
Andersen Aluminum 5th Wheel Hitch
|
|
|
02-16-2020, 01:51 PM
|
#12
|
Site Team
Join Date: Oct 2011
Location: Joppa, MD
Posts: 11,752
|
Like Chuck suggested a picture would help. How do you know that you have hot water in the tank? Is the pipe coming out of the tank hot?
__________________
Marshall
2012 Laredo 303 TG
2010 F250 LT Super Cab, long bed, 4X4, 6.4 Turbo Diesel
|
|
|
02-16-2020, 02:18 PM
|
#13
|
Site Team
Join Date: Jul 2014
Location: Modesto
Posts: 20,345
|
If you can cancel the Girard, I would and order a Truma. From an RV techs point of view way less failures.
__________________
2012 Copper Canyon 273FWRET being towed by a 1994 Ford F350 CC,LB,Dually diesel.
Airlift 5000 bags, Prodigy brake control, 5 gauges on the pillar.Used to tow a '97 Jayco 323RKS.
Now an RVIA registered tech. Retired from Law enforcement in 2008 after 25+ yrs.
|
|
|
02-17-2020, 01:09 PM
|
#14
|
Junior Member
Join Date: Feb 2020
Location: Soddy Daisy
Posts: 13
|
So, I finally figured out that my bypass valve, not check valve, was bad. It didn't matter which direction you turned it, nothing changed. I had to take my water heater out to get to it. $17 later, new valve installed. Just the same, my new tankless water heater will be here tomorrow, so I am ready to install! Thanks again guys for all of the input! ;-)
__________________
Troy & Debra, married 41 years, & Sarah our Borador
2017 Keystone Cougar 28RKS
2015 Ford Super Duty Lariat 6.7
Andersen Aluminum 5th Wheel Hitch
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|