|
09-28-2020, 11:01 AM
|
#1
|
Junior Member
Join Date: Sep 2020
Location: Denver
Posts: 7
|
Water tank not refilling
Hello everyone!
Very new to our new "RV Life."
I have a 2002 keystone challenger with a water filling issue.
After using all of our fresh water, we went to refill the tank again. I refilled it until it began to overflow out of the inlet.
I returned home, to see that the tank (and display) was empty. When i try to fill it up again, within a few seconds it overflows (as if it is full).
I dont have any valves next to the pump, or in the basement, and only have a hot water heater valve.
Any ideas why my tank will not fill?
|
|
|
09-28-2020, 11:06 AM
|
#2
|
Senior Member
Join Date: Aug 2012
Location: Waco, Tx
Posts: 5,457
|
Quote:
Originally Posted by keystone2002
Hello everyone!
Very new to our new "RV Life."
I have a 2002 keystone challenger with a water filling issue.
After using all of our fresh water, we went to refill the tank again. I refilled it until it began to overflow out of the inlet.
I returned home, to see that the tank (and display) was empty. When i try to fill it up again, within a few seconds it overflows (as if it is full).
I dont have any valves next to the pump, or in the basement, and only have a hot water heater valve.
Any ideas why my tank will not fill?
|
If I was a betting man... I'd go with... It's full and the gage is kaput..
__________________
2015 Ford F350 DRW 6.7 Diesel XL
2020 Avalanche 313 RS
|
|
|
09-28-2020, 11:19 AM
|
#3
|
Senior Member
Join Date: Dec 2019
Location: Trinidad,TX
Posts: 973
|
Why do you think it is empty? The guage?
__________________
Woody
Cedar Creek Lake, Texas
2019 Laredo 290 SRL
2019 Ram 2500, 4x4, Cummins diesel
Andersen hitch
|
|
|
09-28-2020, 11:40 AM
|
#4
|
Junior Member
Join Date: Sep 2020
Location: Denver
Posts: 7
|
The gauge says its empty & i have no water when i turn the tap.
Several minutes ago i unscrewed the drain plug under the rig and a ton of water came out.... i put the cap back onafter 10 gals were removed..
Now i'm thoroughly confused.
|
|
|
09-28-2020, 11:42 AM
|
#5
|
Junior Member
Join Date: Sep 2020
Location: Denver
Posts: 7
|
Thank you.
If the gauge is bad, why would i have no water out of the tap when the pump is on?
|
|
|
09-28-2020, 11:51 AM
|
#6
|
Senior Member
Join Date: Nov 2019
Location: Arundel
Posts: 288
|
Quote:
Originally Posted by keystone2002
Thank you.
If the gauge is bad, why would i have no water out of the tap when the pump is on?
|
Start with the basics. Is the pump turned on? If so, when you open a tap does the pump make a noise? If it doesn't, check wiring. If it does, check the pump to see if the intake hose somehow is disconnected or loose. If it is, the pump is sucking air instead of water. If the pump runs be sure to try every tap. Could have a clogged screen on the one you're trying.
Let us know how this goes.
__________________
Jim
2018 Cougar 32RLI
Hercules H-901 tires
CRE3000 w/wet bolts
2021 F-350 4x4 7.3L Godzilla Crew Cab
|
|
|
09-28-2020, 11:59 AM
|
#7
|
Senior Member
Join Date: Mar 2020
Location: Braidwood
Posts: 218
|
If i run mine completely empty it takes a min to get the pump to prime up again. I open 2 faucets and when it starts to flow im good. As asked above do you hear the pump running.
|
|
|
09-28-2020, 12:00 PM
|
#8
|
Junior Member
Join Date: Sep 2020
Location: Denver
Posts: 7
|
Thank you Maineiacs.
When i turn the pump on, it runs just fine.
I fed a smaller diameter hose into the gravity intake tube. No clogs.
I turned on all faucets for 10 mins (hot + cold). No water coming from them.
Next steps?
|
|
|
09-28-2020, 12:01 PM
|
#9
|
Junior Member
Join Date: Sep 2020
Location: Denver
Posts: 7
|
Yes the pump runs the second i turn the pump switch on.
|
|
|
09-28-2020, 12:05 PM
|
#10
|
Senior Member
Join Date: Aug 2012
Location: Waco, Tx
Posts: 5,457
|
Quote:
Originally Posted by keystone2002
Yes the pump runs the second i turn the pump switch on.
|
If you leave the valve open for 2-3 minutes, does the pump continue to run and does it shut off when you close the valve?
__________________
2015 Ford F350 DRW 6.7 Diesel XL
2020 Avalanche 313 RS
|
|
|
09-28-2020, 12:08 PM
|
#11
|
Senior Member
Join Date: Mar 2020
Location: Braidwood
Posts: 218
|
Is or was the hot water tank empty and its filling that up. 10 mins is a long time think it would be there by then
|
|
|
09-28-2020, 12:27 PM
|
#12
|
Junior Member
Join Date: Sep 2020
Location: Denver
Posts: 7
|
We have never filled up the hot water tank. It is currently set to bypass the heater.
|
|
|
09-28-2020, 12:30 PM
|
#13
|
Senior Member
Join Date: Aug 2012
Location: Waco, Tx
Posts: 5,457
|
Quote:
Originally Posted by keystone2002
Thank you Maineiacs.
When i turn the pump on, it runs just fine.
I fed a smaller diameter hose into the gravity intake tube. No clogs.
I turned on all faucets for 10 mins (hot + cold). No water coming from them.
Next steps?
|
Does the pump run when all faucets are closed?
__________________
2015 Ford F350 DRW 6.7 Diesel XL
2020 Avalanche 313 RS
|
|
|
09-28-2020, 12:43 PM
|
#14
|
Senior Member
Join Date: Mar 2020
Location: Braidwood
Posts: 218
|
Sounds like a prime problem or pump just went bad.
|
|
|
09-28-2020, 12:55 PM
|
#15
|
Junior Member
Join Date: Sep 2020
Location: Denver
Posts: 7
|
Quote:
Originally Posted by Javi
If you leave the valve open for 2-3 minutes, does the pump continue to run and does it shut off when you close the valve?
|
The pump will continue to run.
Pump was replaced a month ago and was working the first time i filled the tank - if that helps.
|
|
|
09-28-2020, 01:29 PM
|
#16
|
Senior Member
Join Date: Aug 2012
Location: Waco, Tx
Posts: 5,457
|
Sound to me as if the suction side of the pump is stopped up or the diaphragm is bad.
__________________
2015 Ford F350 DRW 6.7 Diesel XL
2020 Avalanche 313 RS
|
|
|
09-28-2020, 02:01 PM
|
#17
|
Site Team
Join Date: Oct 2011
Location: Joppa, MD
Posts: 11,743
|
pump was recently replaced and did work, then I would check for debris in the hoses. No telling what might be in there in an 18 year old tank. I'd get a strainer and add it to the suction line at the minimum. You could have sucked up some debris and either forced the diaphrame to not seal or damaged it.
Does the system work if connected to city water?
__________________
Marshall
2012 Laredo 303 TG
2010 F250 LT Super Cab, long bed, 4X4, 6.4 Turbo Diesel
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|