|
12-29-2017, 04:22 PM
|
#1
|
Member
Join Date: Nov 2017
Location: Burtonsvlle
Posts: 83
|
Floor heat
Was running the heat in my rv (floor ducted heat) off of a house plug. Not all the registers were blowing hot air. Do I need to be plugged into 30 amp to have all registers to blow heat, or is it broken, or another issue?
|
|
|
12-29-2017, 04:32 PM
|
#2
|
Site Team
Join Date: Jul 2014
Location: Modesto
Posts: 20,351
|
As long as the fan is turning fast enough to allow the gas to ignite, you don’t need to be plugged into a higher amp service. If you have warm air out some and cool air out other registers ( outlets) I would suspect either a blockage of some sort, or maybe the duct has come loose from the heater exchange box.
Locate your heater. You may have to remove the screws holding in a grill to inspect things. The ducts are inserted into holes and rotated, not common but I have seen some come undone or not put on properly. If all the ducts are attached, then you may have kinks or debris in the duct work.
Another issue I have seen is smaller diameter ducts used for longer runs and such. Air like water will take the path of least resistance, and it’s not uncommon to get good flow from the 3” duct and lousy/no flow from the 1 1/2” ducts. Be careful about covering outlets to redirect the heat, as it may cause the furnace to overheat, tripping the high limit switch and shutting down.
__________________
2012 Copper Canyon 273FWRET being towed by a 1994 Ford F350 CC,LB,Dually diesel.
Airlift 5000 bags, Prodigy brake control, 5 gauges on the pillar.Used to tow a '97 Jayco 323RKS.
Now an RVIA registered tech. Retired from Law enforcement in 2008 after 25+ yrs.
|
|
|
12-30-2017, 06:50 AM
|
#3
|
Senior Member
Join Date: Mar 2015
Location: Southeastern Connectiut
Posts: 1,306
|
+1 for Chuckster57...
Your profile doesn't state the age of your camper or if this is a new problem that wasn't there before. If it's a new camper, my advise is to make it the dealers problem. As Chuckster stated, it's not unheard of for the ductwork to be in need of reconnection.
Good Luck,
__________________
Pull Toy
Steve & Jan, Ava & Emma (Mini Schnauzers):
2016 F350 Lariat 4X4 Powerstroke CC/SB "PULLTOY V"
2013 Alpine 3535RE "MAGIC CARPET IV"
Proud Navy Vet!
|
|
|
12-30-2017, 04:01 PM
|
#4
|
Member
Join Date: Nov 2017
Location: Burtonsvlle
Posts: 83
|
It's a brand new camper. Worked before. Will check the lines, then get it to the dealer if needed. Thanks
|
|
|
12-31-2017, 08:00 AM
|
#5
|
Senior Member
Join Date: Oct 2017
Location: Acton
Posts: 127
|
One of ours
This is what we discovered when we pulled out the register on our new 5th wheel.
__________________
2018 Keystone Laredo 298RL
2003 Keystone Laredo 27RL
2019 Ram 3500 Laramie DRW
|
|
|
01-13-2018, 03:57 PM
|
#6
|
Member
Join Date: Sep 2013
Location: Atlanta ga
Posts: 91
|
That is just sad. Even if a worker goes to lunch early you need to fix that when you get back. You just cant close that up. Ugh poor quality control
|
|
|
01-14-2018, 06:34 AM
|
#7
|
Senior Member
Join Date: Sep 2013
Location: Essexville, MI
Posts: 262
|
Quote:
Originally Posted by IRV2
This is what we discovered when we pulled out the register on our new 5th wheel.
|
That is just wrong.
__________________
2014 Passport Elite 31RE
2017 2500HD Crew Cab
|
|
|
01-14-2018, 07:57 AM
|
#8
|
Senior Member
Join Date: Nov 2017
Location: Bragg Creek
Posts: 636
|
Quote:
Originally Posted by IRV2
This is what we discovered when we pulled out the register on our new 5th wheel.
|
Looks like someone went to war in that space.
.
__________________
2016 Bullet 1800RB, UVW 3260, led by a 2005 Chev Silverado Z-71 1500, Crew Cab, 5.3L, 4WD, Tow & Off Road Package with 4.10 Rear Axle, GVR 7000 lbs, Front GWAR 3925 lbs & Rear GWAR 4000 lbs., Payload 1600 lbs., Hellwig 6012 Air Bags. 97' Honda Goldwing GL1500.
Home Base is the Alberta Foothills at 4300 ' ASL.
|
|
|
01-15-2018, 05:59 AM
|
#9
|
Site Team
Join Date: Oct 2011
Location: Joppa, MD
Posts: 11,758
|
If it worked before then that damage is new. Could be the factory did a lousy install that fell apart after use which is what it looks like, but I would suggest you look closely for any evidence of rodents. Those little critters can tear up anything and it would be frustrating to fix it and have a repeat performance by a mouse.
__________________
Marshall
2012 Laredo 303 TG
2010 F250 LT Super Cab, long bed, 4X4, 6.4 Turbo Diesel
|
|
|
01-21-2018, 05:21 AM
|
#10
|
Member
Join Date: Jan 2018
Location: Iowa
Posts: 30
|
Needs to be better staffing of quality control.
|
|
|
01-21-2018, 05:54 AM
|
#11
|
Senior Member
Join Date: Apr 2012
Location: Portland, OR
Posts: 4,223
|
Quote:
Originally Posted by Frisbeekev
It's a brand new camper. Worked before. Will check the lines, then get it to the dealer if needed. Thanks
|
if it worked before, then likely something new is either blocking the duct, or if flexible ducting it may have come disconnect or crushed.
I would check the connections at the furnace first, if you have rigid in floor duct I would make the seal between the duct and furnace better, factories tend to just set the furnace over the hole in the floor! That creates a very poor seal! This is when a roll of good foil duct tape is your best friend. I used to seal all unused covers on our furnace, and all floor connections.
Quote:
Originally Posted by IRV2
This is what we discovered when we pulled out the register on our new 5th wheel.
|
This looks like loading damage, seeing the carpet in the picture looks like a 5er basement. To me looks like somebody shoved something in to the space and knocked the register box loose and tore it duct. Might think about devising protection for that register box!
__________________
Russ & Paula and Belle the Beagle.
2016 Ram Laramie 3500 DRW 14,000# GVWR (New TV)
2005 Copper Canyon 293 FWSLS 32’ GVWR 12,360
Visit and enjoy Oregon State Parks
|
|
|
01-21-2018, 07:39 AM
|
#12
|
Senior Member
Join Date: Oct 2017
Location: Acton
Posts: 127
|
This looks like loading damage, seeing the carpet in the picture looks like a 5er basement. To me looks like somebody shoved something in to the space and knocked the register box loose and tore it duct. Might think about devising protection for that register box!
rhagfo,
My picture wasn't the best and it rotated when uploading, this is not the basement. This is the floor vent beside the kitchen island and dining room slide. I pulled the vent cover off and then took out the register box only to find the ducting was all tore up. We fixed it.
__________________
2018 Keystone Laredo 298RL
2003 Keystone Laredo 27RL
2019 Ram 3500 Laramie DRW
|
|
|
01-21-2018, 09:22 AM
|
#13
|
Senior Member
Join Date: Apr 2012
Location: Portland, OR
Posts: 4,223
|
Quote:
Originally Posted by IRV2
This looks like loading damage, seeing the carpet in the picture looks like a 5er basement. To me looks like somebody shoved something in to the space and knocked the register box loose and tore it duct. Might think about devising protection for that register box!
rhagfo,
My picture wasn't the best and it rotated when uploading, this is not the basement. This is the floor vent beside the kitchen island and dining room slide. I pulled the vent cover off and then took out the register box only to find the ducting was all tore up. We fixed it.
|
Was it rodent damage?
__________________
Russ & Paula and Belle the Beagle.
2016 Ram Laramie 3500 DRW 14,000# GVWR (New TV)
2005 Copper Canyon 293 FWSLS 32’ GVWR 12,360
Visit and enjoy Oregon State Parks
|
|
|
01-21-2018, 10:47 AM
|
#14
|
Senior Member
Join Date: Nov 2017
Location: Picacho, Az
Posts: 6,809
|
Quote:
Originally Posted by rhagfo
Was it rodent damage?
|
Yes! The dirty rats that assembled it, that don't give a rat's a## how it's put together.
__________________
Full-timed 10+ years
Sold '13 Redwood FB
Traded '13 GMC Denali DRW D/A
Replacement undetermined
|
|
|
01-21-2018, 12:10 PM
|
#15
|
Senior Member
Join Date: Apr 2012
Location: Portland, OR
Posts: 4,223
|
Quote:
Originally Posted by travelin texans
Yes! The dirty rats that assembled it, that don't give a rat's a## how it's put together.
|
LOL!
__________________
Russ & Paula and Belle the Beagle.
2016 Ram Laramie 3500 DRW 14,000# GVWR (New TV)
2005 Copper Canyon 293 FWSLS 32’ GVWR 12,360
Visit and enjoy Oregon State Parks
|
|
|
01-21-2018, 01:55 PM
|
#16
|
Senior Member
Join Date: Oct 2017
Location: Acton
Posts: 127
|
What Texas said!!
__________________
2018 Keystone Laredo 298RL
2003 Keystone Laredo 27RL
2019 Ram 3500 Laramie DRW
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|