![Reply](/forums/images/krv/buttons/reply.gif) |
12-23-2018, 05:25 PM
|
#1
|
Junior Member
Join Date: Dec 2018
Location: Henry
Posts: 9
|
Propane consumption
We are on the maiden voyage with our 26sab Cougar. We had both LP tanks filled prior to leaving. They took 13.9 gallons so pretty sure they got filled all the way. We got to our campsite around 3pm with temps in the 50s. It went down to the 30s during the night and 40s today. In the past 24 hours we've gone through both tanks although the green dot says there's gas in them but no furnace. Any suggestions?
|
|
|
12-23-2018, 05:42 PM
|
#2
|
Member
Join Date: Nov 2016
Location: Dayton
Posts: 68
|
I doubt that you are out of propane unless you have a exterior leak. The propane in your tanks will power the furnace for about 40 hours of continuous operation. Sounds like your furnace has a problem.
|
|
|
12-23-2018, 05:45 PM
|
#3
|
Senior Member
Join Date: May 2016
Location: South Jordan, Utah
Posts: 2,223
|
There might be an air bubble in the line. Does the stove work? Water heater?
If so there is gas in the tanks.
Are you using battery power or connected to shore power? Low battery will cause the furnace to not light if the fan can't run.
Using up both tanks in 24 hrs doesn't sound right to me.
__________________
2017 Cougar 279RKSWE
2007.5 Dodge Ram 2500 6.7 Cummins
Retirement Training Completed
I think the little voices in my head have started a chat group.
|
|
|
12-23-2018, 05:49 PM
|
#4
|
Site Team
Join Date: Mar 2011
Location: Gaylord
Posts: 26,996
|
Your tanks may not be empty, the propane may not be "gassing" or you may have a frozen regulator or supply hose. Try warming up your tanks and regulator to see if they will start flowing again.
Doing some math, you can pretty much see how long your 7 gallon tank will last. There are about 92,000 BTU's in a gallon of propane. The furnace is a 35,000 BTU input device. So, you can get about 2.5 hours of furnace operation on a gallon of propane. doing the math, 7 gallons x 2.5 hours per gallon = roughly 17.5 hours. So each tank of propane will run the furnace (CONTINUOUSLY) for about 18hours. Now, the furnace doesn't run 24/7, so you'll get more than a day of use from a tank of propane. How much more depends directly on the temperature outside and the thermostat setting inside.... Most people get 3-4 days on a tank in below freezing (but above zero) temps.
Try warming up your tanks and your regulator, see if it helps. The only way to know for sure how much propane you have is to weigh the tanks.
__________________
John
2015 F250 6.7l 4x4
2014 Cougar X Lite 27RKS
|
|
|
12-23-2018, 05:49 PM
|
#5
|
Site Team
Join Date: Feb 2014
Location: W. Texas
Posts: 17,690
|
Going through both tanks in 24 hours didn't happen without a leak IMO, or mechanical malfunction. I've spent almost 3 days and nights at near zero before one tank ran out much less two. OP needs to dig into this a little more.
__________________
Danny and Susan, wife of 56 years
2019 Ram 3500 Laramie CC SWB SB 6.4 4x4 4.10
2020 Montana High Country 331RL
|
|
|
12-23-2018, 06:39 PM
|
#6
|
Senior Member
Join Date: Apr 2012
Location: Portland, OR
Posts: 4,222
|
13.9 gallos is two full tanks, a truly totally drained cylinder will hold up to 7.1 gallons, so you are only short .3 gallon at most.
__________________
Russ & Paula and Belle the Beagle.
2016 Ram Laramie 3500 DRW 14,000# GVWR (New TV)
2005 Copper Canyon 293 FWSLS 32’ GVWR 12,360
Visit and enjoy Oregon State Parks
|
|
|
12-23-2018, 07:07 PM
|
#7
|
Senior Member
Join Date: Jul 2013
Location: Box Elder
Posts: 2,909
|
Another possibility is, when you removed the cylinders to have them filled, and then reinstalled the cylinders on your trailer, you may have opened the valves too fast and set the excess flow valves in the pigtails. Try turning off the valves on both cylinders, remove both pigtails from the valves, then reinstall the pigtails to the valves, and finally, open the valves VERY SLOWLY. Then try your furnace again. Hopefully this will fix your problem.
__________________
Bob & Becky
2012 3402 Montana
2012 Chevy 2500HD D/A CC
|
|
|
12-23-2018, 09:54 PM
|
#8
|
Member
Join Date: Dec 2016
Location: Edmonton, Alberta
Posts: 59
|
Does your stove work? If so you are getting propane.
__________________
![Canadian Flag](images/smilies/canada-flag.gif)
2013 Fuzion 342
2015 Dodge Ram 3500
|
|
|
12-23-2018, 10:10 PM
|
#9
|
Senior Member
Join Date: Oct 2017
Location: Brisbane Australia
Posts: 708
|
Something else to check:
Do you have an outside cooker? If so, does it have a quick disconnect? If so, it probably has a separate shutoff valve in the line near the disconnect fitting. Make sure that is off.
The quick disconnect fittings on my trailer look the same as what is on my compressor and those types of fittings are notorious for leaking.
Ask me how I know!
|
|
|
12-24-2018, 01:47 AM
|
#10
|
Senior Member
Join Date: Mar 2011
Location: Chesterfield
Posts: 214
|
what is your thermostat set at?
If you have it set high you’ll definitely burn more propane.
I run mine at 68* and run an electric fireplace to offset propane use.
__________________
Mark
2015 Fuzion 325
2020 Ram 3500 DRW 6.7 HO Aisin
Chesterfield, VA.
|
|
|
12-24-2018, 04:16 AM
|
#11
|
Gone Traveling
Join Date: Mar 2018
Location: Ajax
Posts: 431
|
Interesting to know the issue. My guess is a faulty furnace part. The roar of these furnaces do like propane mind you. I wish they could run on electric as well like the HW tank. Also remember they do have that recall on "Atwood" models regarding shut down because of wire contact with an exhaust tube.
|
|
|
12-24-2018, 06:03 AM
|
#12
|
Site Team
Join Date: Jul 2014
Location: Modesto
Posts: 20,341
|
The recall is a Keystone issue not an Atwood issue. It involves the way the wiring was routed.
__________________
![](image.php?s=5c3c1d2b5b769ff2a93580ae308c6e5a&u=14512&type=sigpic&dateline=1418489574)
2012 Copper Canyon 273FWRET being towed by a 1994 Ford F350 CC,LB,Dually diesel.
Airlift 5000 bags, Prodigy brake control, 5 gauges on the pillar.Used to tow a '97 Jayco 323RKS.
Now an RVIA registered tech. Retired from Law enforcement in 2008 after 25+ yrs.
|
|
|
12-24-2018, 07:29 AM
|
#13
|
Gone Traveling
Join Date: Mar 2018
Location: Ajax
Posts: 431
|
It's an Atwood furnace that has wires touching it's exhaust pipe. Either a bad design or the space it limited. Regardless, it can cause the furnace to shut down.
|
|
|
12-25-2018, 02:26 PM
|
#14
|
Senior Member
Join Date: Jul 2013
Location: Box Elder
Posts: 2,909
|
Quote:
Originally Posted by Ruko
Does your stove work? If so you are getting propane.
|
On these rigs, even if you get enough propane to make the burners on the stove work, there may not be enough gas to make the furnace work. The furnace uses a lot more gas.
__________________
Bob & Becky
2012 3402 Montana
2012 Chevy 2500HD D/A CC
|
|
|
12-25-2018, 02:40 PM
|
#15
|
Site Team
Join Date: Mar 2011
Location: Gaylord
Posts: 26,996
|
Quote:
Originally Posted by bobbecky
On these rigs, even if you get enough propane to make the burners on the stove work, there may not be enough gas to make the furnace work. The furnace uses a lot more gas.
|
That's true. The typical stovetop burner is a 5,000 BTU device. The furnace input is 35,000 BTU. So, the furnace uses 7 times the amount of propane as a stovetop burner. The furnace will probably light and operate on about 2/3 normal consumption (a guess not provable fact) but anything less would likely not be enough propane to keep the flame detector closed.
__________________
John
2015 F250 6.7l 4x4
2014 Cougar X Lite 27RKS
|
|
|
12-25-2018, 08:09 PM
|
#16
|
Junior Member
Join Date: Dec 2018
Location: Henry
Posts: 9
|
Thanks to all for your input and insight. I think it was an air bubble. Around 10pm the furnace kicked on and is working fine now. Merry Christmas all!
__________________
![](image.php?s=5c3c1d2b5b769ff2a93580ae308c6e5a&u=28396&type=sigpic&dateline=1574620287)
Sheri and Ray
2013 PrimeTime Crusader 295RST
2018 F150 Platinum
2015 Harley Ultra Classic
|
|
|
12-30-2018, 09:03 AM
|
#17
|
Senior Member
Join Date: May 2017
Location: CT frontier
Posts: 156
|
Quote:
Originally Posted by SheriP
Thanks to all for your input and insight. I think it was an air bubble. Around 10pm the furnace kicked on and is working fine now. Merry Christmas all!
|
If you ever want to see how much propane is in your tanks, just pour some hot water down the side of the tank. Usually you can see a line, but if not just run your hand down the tank. Empty=hot, cooler=propane.
__________________
2017 Cougar XLite 21 RBS
2015 Ram 3500 SLT 5.7 Hemi
|
|
|
12-30-2018, 09:23 AM
|
#18
|
Senior Member
Join Date: Apr 2017
Location: Sandy
Posts: 191
|
Brother in law went through a tank overnight in his fiver. His pigtail was not properly seated. On the other hand, I am parked in southern Utah with overnight temps in the 20-30s. I use a combination of electric heat and propane and use on the average of 1.3 gallons per day in a 2017 Cougar 30RLI.
|
|
|
![Reply](/forums/images/krv/buttons/reply.gif) |
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|